THe NAC Lots-O-BFG KO2 Thread

[vetteboy]

Re: THe NAC Lots-O-Post Thread

The main difference between the PSC pump and the OEM should pretty much be just the orifice size on the high pressure fitting, and that bypass spring pressure tweaked.

(they also are much more careful with inspecting cores for tolerance, and assembly, but the guts are pretty much the same)

You should be able to unscrew the high-pressure fitting from the PSC one and drop the ball/spring/fitting/etc right into the OEM pump.

 

[chedisme]

Re: THe NAC Lots-O-Post Thread

Although neither situation would result in blowing the pump shaft seal.

That would likely happen if the bypass pressure relief is set too high or is stuck. There's a spring that controls it and it's a common homebrew mod to adjust the shimming on try and gain some more pressure over OEM. It's underneath the large hex nut/fitting that the high pressure line screws into.

I did that and shmmed it out too far and all the seals in my box exploded with a bang when I turned the wheel the first time.

 

[Dundy]

Re: THe NAC Lots-O-Post Thread

I did that and shmmed it out too far and all the seals in my box exploded with a bang when I turned the wheel the first time.

I bet you were excited.

 

[Olympus Off Road]

Re: THe NAC Lots-O-Post Thread

well. now i have steering everywhere but idle. close enough.

 

[Luke95]

THe NAC Lots-O-Post Thread

Daily grind

 

[Olympus Off Road]

Re: THe NAC Lots-O-Post Thread

And its warmed up and no steering again.

Both hoses are clear. Maybe one collapses a bit when hot?

 

[ROBZ95Xj]

Re: THe NAC Lots-O-Post Thread

aperently the clamp for the lower radiator hose at the water pump is gone, not sure how it would completely fall off

 

[chedisme]

Re: THe NAC Lots-O-Post Thread

Step one steal lower hoses

Step 2 ?

Step 3 profit

 

[ROBZ95Xj]

Re: THe NAC Lots-O-Post Thread

Replaced the coil in the jeep, had some corrotion where the wire for the distributor connects and 3 nice cracks

 

[dukie564]

Re: THe NAC Lots-O-Post Thread

problem fixed or still smokey smokey cough pop jeep?

 

[ROBZ95Xj]

Re: THe NAC Lots-O-Post Thread

I'll find out tomorow

 

[CTeunuch]

Re: THe NAC Lots-O-Post Thread

Step one steal lower hoses

Step 2 ?

Step 3 profit

Shut up with your showtunes!

 

[chedisme]

Re: THe NAC Lots-O-Post Thread

Shut up with your showtunes!

You're a show tune. And a crappy one to boot!

 

[Olympus Off Road]

Re: THe NAC Lots-O-Post Thread

not that anyone cares, replaced hose, went for about a 40 minute drive, never lost steering this time. but i still have nothing at idle.

close enough.

 

[ROBZ95Xj]

Re: THe NAC Lots-O-Post Thread

I'm gonna show up like 930 10ish

 

[CTeunuch]

Re: THe NAC Lots-O-Post Thread

not that anyone cares, replaced hose, went for about a 40 minute drive, never lost steering this time. but i still have nothing at idle.

close enough.

Sounds like that hose was collapsing, good call. Trash your Jeep for me tomorrow, kthx.

 

[squashman702]

Re: THe NAC Lots-O-Post Thread

Successfully replaced the screen on my phone, next time I'm just buying a new one.

 

[Dundy]

Re: THe NAC Lots-O-Post Thread

Ross and I are gonna show up at around 11.

 

[Olympus Off Road]

Re: THe NAC Lots-O-Post Thread

Sounds like that hose was collapsing, good call. Trash your Jeep for me tomorrow, kthx.

steering blows at idle and when it warms up it gets spotty and whines just like at Nac fest.

Oh well, it isn't any worse than wheeling at nac-fest. and this time my steering box is held on by more bolts.

 

[FlexdXJ]

Re: THe NAC Lots-O-Post Thread

Heads Rhode Island, Tails Cacapoopoopeepeeshire...